| 1. Product and Company Identification |
| Suppliers Product Name |
Violet Ultramarine |
| Common Chemical Name |
Pigment Violet 15 |
| INCI Name |
Violet Ultramarine |
| Supplier |
www.newthymes.com |
| CAS No. |
12769-96-9 |
| EINECS |
N/A |
| JCLS No. |
N/A |
| 2. Composition |
| Ingredient Name |
Ultramarine violet 15 |
| CAS Number |
12769-96-9 |
| Per cent |
100 |
| Exposure Limits |
ACGIH TLV; 5mg/cu.m. (iron oxide fume) |
| Exposure Limits |
OSHA STEL; 10ppm. (iron oxide fume as Fe) |
| . |
| 3. Hazards Identification |
| HMIS RATINGS |
Health:1, Flamability:0, Reactivity:0 |
| Emergency Overview |
Contact with acids liberates hydrogen sulfide, a highly flamable, toxic gas. This risk is greatly reduced with acid resistant grades. |
| Potential Health Effects: Eyes |
May cause mechanical irritation |
| Potential Health Effects: Skin |
None - Non toxic, no action necessary |
| Potential Health Effects: Inhalation |
None - Non toxic, no action necessary |
| Potential Health Effects: Oral LD50 |
Greater than 10 g/kg (RAT) |
| Effects of Overexposure: Acute |
Causes mechanical skin and eye irritation |
| Effects of Overexposure: Chronic |
Prolonged inhalation of dust is known to produce a condition known as siderosis. On X-Rays it appears to be
benign pneumoconiosis and is not associated with pulmonary fibrosis or disability unless there is concurrent exposure to other fibrosis producing materials such as silica.
The TLV is set to protect against siderosis. |
| Carcinogenity |
Not lsted with NTP, IARC or OSHA as a known or suspected carcinogen. |
| 4. First Aid Measures |
| INHALATION |
None - Non toxic, no action necessary |
| INGESTION |
None - Non toxic, no action necessary |
| EYE CONTACT |
As with all powders, may cause irritation to sensitive skin - wash with soap and water. If irritation persists seek medical advise. |
| SKIN CONTACT |
As with all powders, may cause mild irritation to eyes. - rinse immediately with plenty of water, also under the eyelids, for at least 10 minutes. if problems persist seek medical advise. |
| 5. Fire-Fighting Measures |
| Flammable properties |
Non-Flammable |
| Flash Point |
None |
| Flammable Limits |
Not applicable |
| Hazardous combustion products |
None |
| EXTINGUISHING MEDIA; |
Dry chemical, CO2 for small fires. Use foam for large fires. |
| FIRE FIGHTING INSTRUCTIONS |
None |
| UNUSUAL FIRE AND EXPLOSIVE HAZARDS |
None |
| 6. Accidental Release Measures |
| Small/large spills |
Clean up using dry procedures: avoid dusting. |
| 7. Handling and Storage |
| Handling |
Good industral hygiene practice requires that employee exposure be maintained below TLV. This is preferably achieved through the provision
of adequate ventilation where necessary. Where dust cannot be controlled in this way, personal respiratory protection should be employed. |
| Storage |
Store in a clean, dry area at ambient temperatures in original unopened containers. Conditions of high humidity may require
storage in a controlled envirnment. Store at temperatures well below 140F |
| 8. Exposure Control/Personal Protection |
| Engineering Controls |
Use with adequate ventilation to meet exposure limits listed in section 2 |
| RESPIRATORY CONTROL |
NIOSHA approved dust respirator if overexposure potential exists. |
| Skin Protection |
Leather or rubber gloves |
| Eye Protection |
Safety glasses/goggles or face shield recommended. |
| 9. Physical and Chemical Prperties |
| Appearance |
Violet Powder |
| Boiling Point |
Not applicable |
| Vapor pressure |
Not applicable |
| VAPOR DENSITY |
Not applicable |
| Solubility in water |
Insoluble |
| Specific Gravity |
>N/A |
| pH |
N/A |
| Odor |
None |
| Odor threshold |
Not applicable |
| 10. Stability and Reactivity |
| STABILITY |
Stable |
| MATERIALS TO AVOID |
Strong oxidizers |
| CONDITIONS TO AVOID |
A small amount (less than 0.1% As Cr) of reversion to hexavalent chromium may occur if this product is exposed to elevated temperatures. |
| HAZARDOUS DECOMPOSITION PRODUCTS |
None |
| HAZARDOUS POLYMERIXATION |
None |
| 12. Toxicological Information |
| There are no known dangerous acute or chronic effects associated with the use of this material. This product is not considered to be known or suspected carcinogenic by
NTP, IARC or OSHA. |
| Ecological Information |
No ecological hazards are associated with this product. |
| 13. Disposal Considerations |
| US: Discarded product is not a hazardous waste under RCRA, 40 CFR 261 |
EC: Dispose of material in accordance with appropriate regulations |
| 14. Transport Information |
| Class/Division: not restricted |
. |
| 15. Regulatory Information Information |
US: This material is intended to be used as a cosmetic ingredient and is exempt from
Toxic Substances Control Act (TSCA) regulation (40 CFR 710) when used as such. Do not use for other purposes.
EC: This material is not classed as "Dangerous" according to the health and physical properties criteria of the
EU Directives on the classification of substances and preparations. |
Information in this material safety data sheet is compiled from our general experience and data obtained from various technical publications
and is furnished without warranty. The responsibility for the adoption of appropriate safety precautions rest solely with user. While
www.newthymes.com believe that the information provided herein is accurate at the date hereof, no responsibility for its
completeness or accuracy can be assumed. This information is provided solely for consideration and investigation by the user. Revised Jan 03.
|
Ingredients